PARKER, Judge.

Under the North Carolina Workers’ Compensation Act, an injury arising out of and in the course of employment is compen-sable only if that injury was caused by an “accident,” which must be a separate event preceding and causing the injury. Jackson v. Highway Commission, 272 N.C. 697, 158 S.E. 2d 865 (1968); Rhinehart v. Market, 271 N.C. 586, 157 S.E. 2d 1 (1967); Hensley v. Cooperative, 246 N.C. 274, 98 S.E. 2d 289 (1957). The initial question raised by defendant employer on this appeal is whether the Commission properly found that plaintiff’s injury resulted from such an “accident.”

*25 Defendant’s first contention is that the evidence does not support the Commission’s Findings of Fact Nos. 2 and 6. Finding of Fact No. 2 of the full Commission’s Opinion and Award recites:

2. On 19 October 1976 the plaintiff, in the course of her duties, was pulling a rod out of a roll of cloth, this activity a part of the plaintiff’s regular and customary job. On this occasion, the withdrawal of the rod was more difficult than usual. The extraordinary effort the plaintiff exerted in her effort to withdraw the rod injured her back and caused an onset of pain. Plaintiff continued to work with difficulty due to pain until 3 November 1976.

Finding of Fact No. 6 of that Award reads:

6. Plaintiff suffered 19 October 1976 an injury by accident arising out of and in the course of her employment. As a result, she became totally disabled 3 November 1976.

If there was any competent evidence before the Commission to support these findings they are, of course, conclusive on this appeal. Cole v. Guilford County, 259 N.C. 724, 131 S.E. 2d 308 (1963); Vause v. Equipment Co., 233 N.C. 88, 63 S.E. 2d 173 (1951).

As to Finding of Fact No. 2, plaintiff stated several times in her testimony before the Deputy Commissioner that although the rods were sometimes hard to pull out, the night the injury occurred it was “extra hard” or “unusually hard” to doff that particular machine because it was “extra tight.” She stated, that as a result, “I had to strain to get it out.” Plaintiff placed her knees around the roll of cloth, pulled up on the rod and experienced pain in her spine such that she could hardly move. Although plaintiff admitted that she was doing what she normally did when a rod was hard to pull out and that this was part of her normal job, this testimony did not contradict that concerning the extra strain which she exerted to pull the rod out of that machine. Further, although defendant offered into evidence a statement made by plaintiff and recorded by defendant’s insurance carrier’s claim supervisor while plaintiff was hospitalized in which plaintiff stated that several of the machines were hard to doff on the night the injury occurred, the weight to be accorded that evidence was for the Commission to determine. The Commission merely chose to rely on plaintiff’s testimony before the hearing examiner, and that testimony was sufficient to support Finding of Fact No. 2.

*26 As to Finding of Fact No. 6, we also find that there was sufficient evidence to support the finding that plaintiff suffered an injury by “accident.” Our Supreme Court has defined the term “accident” as used in the Workers’ Compensation Act as “an un-looked for and untoward event which is not expected or designed by the person who suffers the injury.” Hensley v. Cooperative, supra at 278, 98 S.E. 2d at 292; accord, Rhinehart v. Market, supra. The elements of an “accident” are the interruption of the routine of work and the introduction thereby of unusual conditions likely to result in unexpected consequences. Pardue v. Tire Co., 260 N.C. 413, 132 S.E. 2d 747 (1963); Faires v. McDevitt and Street Co., 251 N.C. 194, 110 S.E. 2d 898 (1959). Of course, if the employee is performing his regular duties in the “usual and customary manner,” and is injured, there is no “accident” and the injury is not compensable. O’Mary v. Clearinq Corp., 261 N.C. 508, 135 S.E. 2d 193 (1964).

In support of its contention that the facts of the present case do not satisfy the requirements of injury by “accident,” defendant relies upon the decision of our Supreme Court in Hensley v. Cooperative, supra, and of this Court in Smith v. Burlington Industries, 35 N.C. App. 105, 239 S.E. 2d 845 (1978). In Hensley, the plaintiff had been employed for two and one-half years to “turn chickens”. His duties required him, while standing, to twist and pick up a wire basket containing six chickens and then to return to a normal position and dip the basket in hot water. On one occasion, he twisted as usual and suffered an injury. On appeal from an award of the Industrial Commission granting compensation, the Supreme Court reversed on the grounds that there was no evidence of “accident” other than the injury itself.

Similarly, in the Smith case, the plaintiff’s back was injured as he was turning to lift two brass bars. This Court held that the Commission properly denied compensation because the evidence showed that plaintiff was doing nothing unusual or different at the time of his injury.

We find each of the above cases distinguishable from that now before us. In each case, the injured employee was performing his usual duties at the time the injury occurred, and there was no extra exertion required to perform those duties at that time. That is, there was neither evidence of an interruption of the work *27 routine nor the introduction of unusual circumstances. In the present case, both of those elements are present. There is competent evidence in the record that, on the occasion of plaintiff’s injury withdrawal of the rod was unusually difficult because the roll of cloth was “extra tight,” thus interrupting what was plaintiff’s normal work routine. Further, there is competent evidence that the effort which plaintiff exerted was unusual. Our Supreme Court has recognized that evidence of the necessity of extreme exertion is sufficient to bring into an event causing an injury the necessary element of unusualness and unexpectedness from which accident may be inferred. Jackson v. Highway Commission, supra; Gabriel v. Newton, 227 N.C. 314, 42 S.E. 2d 96 (1947). Thus, the Commission was warranted in finding as a fact and concluding as a matter of law that plaintiff suffered an injury “by accident” on 19 October 1976.

In its Finding of Fact No. 6, the Commission also found that plaintiff became totally disabled 3 November 1976. Plaintiff testified that on 4 November 1976 she consulted a surgeon in Shelby, and after a few days of rest entered the hospital for four weeks. The day after Thanksgiving 1976 plaintiff underwent an operation, and after she returned home on 4 December 1976 she remained in bed until mid-February 1977. During that time she was not employed. As used in the Workers’ Compensation Act, the term “disability” means incapacity because of injury to earn, in the same or any other employment, the wages which the employee was receiving at the time of injury. G.S. 97-2(9); see, Watkins v. Motor Lines, 279 N.C. 132, 181 S.E. 2d 588 (1971). Although there is a one-day discrepancy between evidence in the record as to the exact date plaintiff ceased work because of her injury and the date referred to in the Commission’s findings, that discrepancy is not crucial to the finding of total disability. That finding is adequately supported by plaintiff’s evidence of her medical treatment involving complete bed rest and subsequent hospitalization, i.e. her total incapacity to work and to earn wages, and that finding in turn supports the Commission’s award of compensation. As the Commission itself noted, the record is silent on the question of what date, if yet, plaintiff reached maximum recovery, and on the question of her permanent partial disability, if any. For this reason, the case must be remanded for further hearings on these questions.

*28 That portion of the opinion and award of the full Commission determining plaintiff’s entitlement to compensation is affirmed, and the case is remanded for further hearings on the issues noted.

Affirmed in part and remanded.

Chief Judge MORRIS and Judge HILL concur.