49 A. 852 | Conn. | 1901
The plaintiff, who was employed by the defendant as an elevator boy in its factory where it was engaged in the manufacture of guns, was injured by a flying *47 fragment of an emery-wheel which burst in one of the rooms of the factory. The defendant had purchased the wheel of a manufacturer of high reputation, but no sufficient test had been made of the wheel prior to its shipment to the defendant. The trial court found that "the only reliable mode to test such a wheel is to place it on a shaft and set it in motion in a protected place, and gradually increase the speed until the desired velocity is attained," and that this was known to the defendant.
It was believed by the manufacturer that the wheel was capable of sustaining a strain equal to more than 700 revolutions per minute, and it was made in the same manner as other wheels made by this manufacturer and in use in many large manufactories in this and other countries.
The finding states that upon the removal of the wheel from the box, at the defendant's factory, it was examined and appeared to be without defects of any kind; that it was then placed upon the shaft and upon the machine called the emery-grinder and secured in its bearings; that the grinder was belted to the counter-shaft so that the wheel could not exceed 600 revolutions per minute, "in order that it might be at all times safe for the use of its employees;" that the defendant's foreman "in charge of the machine" applied the power and ran it a short time at the highest speed at which it could be run by the machinery as then arranged, while the foreman watched it to see that it was running in its true position. The wheel appeared to him to be evenly balanced and running properly. The wheel was then stopped and the foreman made an examination of all nuts and fastenings by which it was secured, and it appeared to be in proper condition. The power was then applied the second time, "when almost immediately" the wheel burst and the plaintiff was struck.
It is to be observed that at the time of the accident the wheel was not in use by the defendant's operatives, but was in charge of the defendant's foreman and was being tested by him, assisted, as indicated by the finding, by a fellow-workman, preparatory to being placed in use. *48
The finding says that the defendant's foreman testified that just prior to staring the wheel he notified all persons to leave the room except a fellow-workman; that the plaintiff, who by instruction was in the room where the elevator was then at rest, did not hear any notice to leave the room and did not know that there was any danger attendant upon the starting of the emery-wheel, and that proper precautions were not taken to keep other employees out of the room while the defendant was putting up and starting the wheel.
In his memorandum of decision the trial judge says that the test that was reasonably sure was "an actual trial of the wheel at the speed it was expected to run when in use," and that "it was the defendant's duty to take this precaution, without exposing its employees to the peril arising in case the wheel should prove defective."
The record seems to us to show that the trial court held the defendant liable upon a cause of action not described in the complaint.
The negligence of the defendant alleged in the complaint was its disregard of its legal duty "to furnish safe and secure machinery in the prosecution of its said business," in providing in one of its rooms "an unsafe, defective and insecure machine, to wit, an emery-grinder," the defects in which are described as, first, the want of a proper covering or protection; second, that the emery-wheel was placed in the machine in a negligent manner by unskilled workman; and third, that the emery-wheel was defective when placed in the machine, all of which it is alleged the defendant well knew. In what respect the wheel was unskillfully placed upon the machine, or wherein the emery-wheel was defective, or how the machine was thus rendered unsafe, is not alleged. It is alleged that the accident happened by reason of the defendant's negligence as aforesaid, while the machine was in operation.
The finding shows that the machine upon which the wheel was placed was a proper one for the work intended for it; that the accident was not caused by any unskillfulness in the manner in which the wheel was put on the machine, but by *49 the bursting of the wheel; that the defendant had no knowledge that the emery-wheel was defective, and that the fact that the wheel was defective was not chargeable to its negligence.
The facts found disprove the acts of negligence alleged, and the acts of negligence found are not averred in the complaint. They prove that the accident was not caused by the failure of the defendant to exercise reasonable care to provide safe machinery in the prosecution of its business, but that the defendant's foreman was testing the machine and that if he had not before the accident fully completed the very trial of the wheel which the court finds is the only reliable one, namely, the actual running of the wheel up to the desired velocity, the fault of the defendant, if it was guilty of negligence, was in not notifying the plaintiff to leave the room or warning him of the danger of remaining before the wheel was started the second time. This act of negligence is not alleged in the complaint, and even upon a hearing in damages after a default a judgment for substantial damages cannot be based upon a failure of duty upon the part of the defendant not averred in the complaint. Pitkin v. New York N.E. R. Co.,
To avoid liability for more than the nominal damages conclusively admitted by the default, the defendant was only required to prove that the injury complained of was not caused by his negligence, as alleged. Walsh v. Hayes,
We have no occasion to discuss the question of whether proof that an employer had purchased of an experienced and reputable manufacturer a piece of machinery as perfect and safe to put into immediate use, might of itself constitute sufficient proof of the exercise of reasonable care in furnishing safe machinery for his employees, since it appears by the finding not only that the defendant knew that an actual trial *50 of the wheel was necessary in order to determine whether it could safely be used, but also that the defendant either had tested, or was engaged in testing, the wheel when the accident occurred.
There is error and the case is remanded to be proceeded with according to law.
In this opinion the other judges concurred.