Appellants, Rickey L. Riley, Joan M. Riley and Coby Riley, bring this appeal from the judgment entered by the Court of Common Pleas of York County on a directed verdict in favor of appellee Warren Manufacturing, Inc. We affirm.
FACTS:
The facts in this case are not in dispute. Appellee Warren Manufacturing, Inc. (‘Warren”) is a manufacturer of bulk feed trailers which are used to transport animal feed from suppliers to various farms. Warren equips its trailers with an airlock device, manufactured by A.W. Stauffer & Sons (“Stauffer”), which forces the feed from the trailer through a discharge tube located at the rear of the truck. The airlock mechanism consists of eight blades or vanes that rotate at a high speed in order to expel the feed. These blades are located 6% inches from the end of the discharge tube. A steel hose or “elbow” is attached to the discharge tube to prevent the feed from blowing in all directions. Agricultural Commodities, Inc. (“AgCom”) used such a bulk feed trailer, which it had purchased from Warren, to supply its customers with bulk feed.
On August 2, 1991, James Krichten, an employee of AgCom was operating the bulk feed trailer. Krichten’s grandson, Coby Riley, (“Coby”) accompanied him as he made his regular stops to deliver the feed. When Krichten and Coby returned to AgCom, Krichten activated the airlock in order to discharge residue. At the same time, Coby placed his fingers into the discharge tube, making contact with the blades of the airlock device. As a result, Coby had his left index, middle, and ring finger, along with the tip of his left pinky cut off. Surgeons were able to re-attach his index and middle fingers; Cob/s ring finger was not located.
*389 Appellants sued AgCom, Stauffer and Warren. AgCom and Stauffer settled with appellants before trial; the case proceeded to trial against Warren on the sole theory of products liability. Appellants contended that the design of the trailer was defective because the opening to the airlock was unguarded and unsafe. At the close of appellants’ evidence, Warren moved for a compulsory non-suit, which was denied. However, after presenting its case, Warren moved for a directed verdict, which was granted. The basis of the directed verdict was that appellants failed to prove that the bulk-feed trailer was unreasonably dangerous. Appellants’ motions for post-trial relief were denied and this appeal followed.
DISCUSSION:
The issue in this case is whether the trial court erred in directing a verdict in favor of appellee on the ground that the trailer design was not “unreasonably dangerous.”
In reviewing a trial court’s decision to direct a verdict in favor of a defendant, we must view the evidence presented in the light most favorable to plaintiff and determine whether plaintiff failed to prove his case as a matter of law.
Edwards v. Brandywine Hospital,
Court control of jury action in products liability cases is more extensive than in an ordinary negligence action.
Dambacher by Dambacher v. Mallis,
In products liability cases, § 402A of the Restatement (Second) of Torts has been adopted as the law of this Commonwealth,
Webb. v. Zern,
The question of whether a product is unreasonably dangerous is a question of law.
Azzarello, supra
at 556,
[T]he gravity of the danger posed by the challenged design; the likelihood that such danger would occur; the mechanical feasibility of a safer design; and the adverse consequences to the product and to the consumer that would result from a safer design, (citation omitted).
Id.
at 50 n. 5,
(1) The usefulness and desirability of the product — its utility to the user and to the public as a whole.
(2) The safety aspects of a product — the likelihood that it will cause injury, and the probable seriousness of the injury.
(3) The availability of a substitute product which would meet the same need and not be as unsafe.
(4) The manufacturer’s ability to eliminate the unsafe character of the product without impairing its usefulness or making it too expensive to maintain its utility.
(5) The user’s ability to avoid danger by the exercise of care in the use of the product.
(6) The user’s anticipated awareness of the dangers inherent in the product and their avoidability, because of general public knowledge of the obvious condition of the product, or of the existence of suitable warnings or instructions.
*392 (7) The feasibility on the part of the manufacturer, of spreading the loss of setting the price of the product or carrying liability insurance.
These additional factors were derived from an article by Dean John Wade of Vanderbilt University, “On the Nature of Strict Tort Liability for Products,” 44 Miss.LJ. 825, 837-38 (1973).
It is appellants’ contention that the appellee was required to persuade the Court as a matter of law on each of the 7 factors identified by Wade in determining whether a product is unreasonably dangerous. 3 We disagree. The above factors are merely suggestions for the Court to consider when making its social policy analysis.
In the instant case, the trial court considered the Azzarello standard as well as the ‘Wade factors” outlined in Dambacher, and held as a matter of law that the bulk feed trailer was not unreasonably dangerous. 4 For the following reasons we agree with the trial court’s conclusion.
Appellants offered the testimony of Dr. Charles Batterman as an expert in the area of engineering design, human factors and safety engineering. Although Dr. Batterman testified that in his opinion the trailer was unsafe because the blade vanes were easily accessible to anybody who put their hands *393 into the discharge tube, and that the opening to the discharge tube was completely unguarded, he nevertheless conceded that there was no reason to put a hand inside the discharge tube. Further, appellants offered no evidence of other injuries involving an airlock, and Russell D. Warren, owner of Warren Manufacturing, testified that he knew of no such injuries. 5
Based on the above summarized testimony, the trial court concluded: “There simply is not any evidence in the record that this type of injury was likely to occur.” Slip. Op. Riley v. Warren, Court of Common Pleas of York County, No. 92 SU 000001 01, November 9, 1995, p. 23. The evidence established that a person could not be injured without placing a hand into the discharge tube, and that there was no reason to place a hand into the discharge tube while the machine was engaged. Thus, the evidence did not demonstrate that the trailer was unsafe as designed for its intended use. 6
Dr. Batterman also offered eight design considerations that he contended could have prevented someone from contacting *394 the blade vanes if he or she put their hands into the discharge tube: 7 1) a screen at the opening tube; 2) a longer discharge tube so that a hand could not reach the blades, 4) a curved tube, 5) an “interlock” that would not allow the blades to turn unless you inserted something (like an “elbow”) into the tube; 6) a spring-loaded door at the end of the tube; 7) a hinged pipe extension to the tube; 8) a flexible piece of tubing permanently attached to the end of the tube. However, Dr. Batterman did not conduct any tests or show any blueprints, to determine whether any of his suggestions were feasible or cost efficient. Indeed, on cross-examination, he conceded that some of his suggestions were impractical. Dr. Batterman further testified that he had never examined a bulk-feed trailer besides the one in this case, and, in evaluating the possible alternatives, he considered neither the total use of the product, nor the effect his suggestions would have on the utility of the bulk feed trailer.
The trial court was not impressed with appellants’ expert due to his lack of familiarity with the product in question and the “speculative” nature of his testimony. Essentially, the court concluded that this evidence was inadequate as a matter of law to show that the product was unreasonably dangerous. 8 We agree and detect no error in the court’s resolution of this issue.
However, even if the judge had erred in peremptorily taking the issue of whether the trailer was unreasonably dangerous from the jury, there was an alternative basis for doing so; and on this alternative basis the trial court’s deci *395 sion to direct a verdict was correct. 9
In
Schriner v. Pennsylvania Power and Light Co.,
When we distill § 402A into its constituent elements, we find that the following are necessary to an appropriate application of this section:
1. a product;
2. a sale of that product;
3. a user or consumer;
4. defective condition, unreasonably dangerous; and
5. causation — that the product caused physical harm to the ultimate user or consumer or to his property.
and if any of these requisite elements remain unsatisfied, § 402A has no applicability.
Id.
at 185,
The commentary to the Restatement defines “user” as follows:
“User” includes those who are passively enjoying the benefit of the product, as in the case of passengers in automobiles or airplanes, as well as those who are utilizing it for the purpose of doing work upon it, as in the case of an employee of the ultimate buyer who is making repairs upon the automobile which he has purchased.
Thus far the courts, in applying the rule stated in this Section, have not gone beyond allowing recovery to users and consumers, as those terms are defined in Comment l. Casual bystanders, and others who may come in contact with the product, as in the case of employees of the retailer, or a passer-by injured by an exploding bottle, or a pedestrian hit by an automobile, have been denied recovery. There *396 may be no essential reason why such plaintiffs should not be brought within the scope of the protection afforded, other than that they do not have the same reasons for expecting such protection as the consumer who buys a marketed product; but the social pressure which has been largely responsible for the development of the rule stated has been a consumers’ pressure, and there is not the same demand for the protection of casual strangers.
RESTATEMENT (2d) TORTS § 402A, Comments (1) and (o).
Appellants contend that Coby was a user of the trailer merely “by coming into contact with the trailer and being injured while in its proximity.” (Appellant’s Brief, p. 26). Their argument can be summarized as follows: because it was “foreseeable” that someone might place their hand inside the discharge tube and come in contact with the blades, anyone who does so, is, a priori, a “user,” and should recover because it is “the foreseeability that certain acts or injuries will occur” which determines who is a user of a product.
However, it is inappropriate to discuss foreseeability, a negligence principal, when analyzing a products liability theory.
10
See Dambacher, supra
at 55,
Simply put, foreseeability is a factor of the “reasonable man” standard in negligence and has no place in a products liability case.
Berkebile, supra
at 97,
Recently, the Third Circuit had occasion to discuss specifically who is an “intended user.” In
Griggs v. BIC Corp.,
In
Klemka v. Bic,
*399
The decisions in
Griggs,
and
Klemka
are consistent with
Ellis v. Chicago Bridge & Iron Co., supra,
where this Court held that the test to determine whether a seller has a duty to place a warning on his product depends upon “the knowledge and realization of the danger that would be possessed by the ordinary consumer who purchases or uses the product.”
Id.
at 229,
§ 402A. Special Liabilty of Seller of Product for Physical Harm to User or Consumer
(1) One who sells any product in a defective condition unreasonably dangerous to the user or consumer or to his property is subject to liability for physical harm thereby caused to the ultimate user or consumer, or to his property, if
*400 (a) the seller is engaged in the business of selling such a product, and
(b) it is expected to and does reach the user or consumer without a substantial change in the condition in which it is sold.
(2) The rule stated in Subsection (1) applies although
(a) the seller has exercised all possible care in the preparation and sale of his product, and
(b) the user or consumer has not bought the product from or entered into any contractual relation with the seller.
Restatement (Second) of Torts, § 402A (1965) (emphasis added)
In the present case Coby was clearly, in the words of the Court in
Klemka,
a “reasonably obvious unintended user.”
Klemka, supra
Thus, the trial court correctly concluded that AgCom and its employees, as the consumers and operators of the product, were the “users” who were afforded protection under § 402A. Because a child was never the intended consumer of the product and had no reason to come in contact with it, Coby was clearly an “obvious unintended user.” Consequently, § 402A relief was not available to him.
In summary, any motorized vehicle carries certain substantial risks to the user, and such products are not unreasonably dangerous merely because they may be involved in accidents or because an operator may be injured during their use.
See Monahan v. Toro Co.,
CONCLUSION:
Here the benefits of the trailer were clear, no feasible alternatives were shown to exist, the trailer was not defective, and there was no evidence that a risk of injury existed for intended users using the machine for its intended use. Hence, the trial court did not err in directing the verdict in favor of appellee.
Consequently, the judgment entered by the Court of Common Pleas of York County is affirmed.
Notes
. § 402A reads in full as follows:
"(1) One who sells any product in a defective condition unreasonably dangerous to the user or consumer or to his property is subject to liability for physical harm thereby caused to the ultimate user or consumer, or to his property, if
(a) the seller is engaged in the business of selling such a product, and
(b) it is expected to and does reach the user or consumer without a substantial change in the condition in which it is sold.
(2) The rule stated in Subsection (1) applies although
(a) the seller has exercised all possible care in the preparation and sale of his product, and
(b) the user or consumer has not bought the product from or entered into any contractual relation with the seller.”
Restatement (Second) of Torts, § 402A (1965).
. In
Azzarello v. Black Bros. Co., Inc., 480
Pa. 547, 558,
The mere fact that we have approved Section 402A, and even if we agree that the phrase "unreasonably dangerous” serves a useful purpose in predicting liability in this area, it does not follow that this language should be used in framing the issues for the jury’s consideration. Should an ill-conceived design which exposes the user to the risk of harm entitle one injured by the product to recover? Should adequate warnings of the dangerous propensities of an article insulate one who suffers injuries from those propensities? When does the utility of a product outweigh the unavoidable danger it may pose? These are questions of law and their resolution depends upon social policy.
Id.
at 557,
. Appellants rely on
Shetterly v. Crown Controls Corp.,
However, nowhere in this case, or subsequent cases, does the federal court hold that each of the 7 factors must be proven. They are merely factors to be considered in the Court's overall social policy analysis.
. We note that the social utility of the bulk-feed trailer at issue here was undisputed. Robert Ross McEllhiney, who was qualified as an expert in animal feed manufacturing and transportation of animal feeds, testified that bulk feed trucks were developed in the late 1950's, primarily for the purpose of delivering feeds from the producing plants to the customer. The advantages of the bulk-feed trailer are that it can haul bulk commodities more conveniently to the farmers and can reduce the price of feed by $25 to $35 a ton.
. We reject appellants’ argument that the trial court erred in considering the lack of evidence of other injuries because the trailer was custom designed to fit AgCom’s specifications. The trial court relied on Mr. Warren’s testimony that while certain properties of the trailer were customized for AgCom, the basic structure of the trailer, and the location of the airlock/discharge tube was the standard in the industry.
. Appellants also argued that the trailer was defective because Warren never included safety information or directions on how to clean out the airlock. Comment (j) to § 402A states, in relevant part: "In order to prevent the product from being unreasonably dangerous, the seller may be required to give directions or warning, on the container, as to its use.”
See Ellis v. Chicago Bridge & Iron Co.,
.
In Dambacher by Dambacher v. Mallis,
. Appellants also argue that the trial court failed to view the evidence in a manner most favorable to the appellants when there were credibility and disputed factual issues regarding design alternatives which should have been left to the jury to decide. This is not correct. The trial judge here ruled that, even accepting appellants’ expert testimony as true, it still did not satisfy this burden.
. An appellate court may affirm the decision of the trial court if it is correct on an alternative basis.
Matos v. Rivera,
. The distinction in Pennsylvania between products liability and negligence was aptly explained in
Griggs v. BIC Corp.,
In strict liability, the focus is on a defect in the product, regardless of fault, [Lewis v. Coffing Hoist Div., Duff-Norton Co.,515 Pa. 334 , 341,528 A.2d 590 , 593 (1987)], and that defect is determined in relation to a particular subset of the general population: the intended user who puts the product to its intended use. In negligence, the focus is on the reasonableness of a defendant's conduct, Id., and this reasonableness is determined in relation to a different subset of the general population, and that is conceivably broader: anyone who foreseeably may be subject to an unreasonable risk of foreseeable harm.
In strict liability, the plaintiff need not show fault, but only prove a product defect. A product cannot be defective when its design and performance meet all of the requirements of the intended user, regardless of the foreseeability of misuse by unintended users. In negligence, the plaintiff must prove fault of the manufacturer, which is an element not required in strict liability law. The scope of inquiry, however, expands because of the duty to unintended but foreseeable users.
*397 Id. at 1438.
. The Court did note that the manufacturer may have had a duty under negligence principles to manufacture childproof lighters if it was foreseeable that children would use the lighters to start fires..
. Additionally, we note that this analysis comports with the law in other jurisdictions:
Cottom v. McGuire Funeral Service,
