Prattville Cotton Mills Co. v. McKinney

59 So. 498 | Ala. | 1912

MAYFIELD, J.

— This action is brought by a servant against the master to recover damages for personal injuries alleged to have been proximately caused by the negligence of the master, or of its servants or agents, for which the law holds the master liable.

The complaint originally contained 13 counts, but it was tried upon counts 1, 2, 4, 6, 7, 8, 9, and 10.

Counts 1 and 2 were under the first subdivision of the Employer’s Liability Act (Code 1907, § 3910), as for defects in the ways, works, machinery, etc. Counts 4 and 6 were under the second subdivision, as for the negligence of a servant intrusted with superintendence, while in the exercise of such superintendence. Counts 7 and 8 were based upon the common-law duty of the master to use reasonable diligence and care to furnish the servant a safe place in which to work, and safe appliances with which to work, and to exercise care to maintain the same in a safe condition and in repair. Counts 9 and 10 were for failure to warn the servant, who was alleged to be inexperienced, of the dangers attending the performance of the duties assigned to plaintiff.

To these various counts the defendant demurred, but the record fails to show any judgment or order or ruling on the demurrer. Therefore we cannot pass upon the sufficiency of the counts, and all must be treated as if not demurred to.

To these counts the defendant pleaded the general issue, contributory negligence, and assumption of risk. There were many of these pleas. A demurrer to all the special pleas was interposed, • but the judgment entry shows no ruling thereon. Moreover, the record proper is in bad condition.

We are therefore required to guess or to presume the issues upon which the case was actually tried, and all intendments must be indulged in favor of the rulings of the trial court on the demurrers to the complaint and to the special pleas.

The plaintiff is a minor, between 15 and 16 years of age. The defendant is a corporation engaged in the operation of a cotton mill in this state. The plaintiff was employed by the defendant, in its business, and at the time of the injury was engaged in the particular business of stranner, and worked at a stranning machine, which is a part of the machine for making cotton rope. At the time of his injury he had been Avorking at this particular machine only a few7 days, less than a week, though he had been employed in the mill for several years at other and less dangerous AVork. The stranning machine at Avhich plaintiff Avorked had connected Avith it a line of steel shafting, about 14 feet long, on which revolved pulleys wdth belts for running the machinery. This section of shafting had an iron band or collar around it, through AAdiich passed a set screw, for holding the pulleys in position. This screAV Avas about three-eighths of an inch in diameter, with a square head about one-half inch in size, and projected above the collar about three-eighths of an inch. This machinery Avas required to be cleaned by the employee w7ho operated it, on Saturday. It w7as stopped at 2:15 p. m., on Saturday, and the mill Avas closed at 3 p. m., on that day. This was arranged and intended to allow 45 minutes in Avhich to clean up the machinery, SAveep the building, etc., before the operatives should leave for the week.

This stranning machine which the plaintiff operated had this shaft above'referred to, which revolved very rapidly, making 400 or 500 revolutions per minute. Plaintiff was attempting to clean the machine while it ivas in operation, by wiping with waste threads or yarn-which was wrapped around his hands; and this thread or waste caught upon the head of the set screw, and thus drew his hand around the shafting, tearing off a part of his hand and arm.

The plaintiff claims that he did not know of the presence of this set screw and its projecting head, ivhich caught the yarn and thus drew his hand around the pulley and inflicted the injury complained of.

Under the present state of this record, it appears that this case may have been tried upon a hundred or more issues, and, except as the evidence may show it, it is impossible to know which were abandoned, and which were the most relied upon for recovery, or for defense. Our investigation of the record is therefore rendered more difficult and uncertain. It is stated by counsel — and the record seems to bear out the statement — that the main issues relied on for a recovery by the plaintiff were a defect in the machinery in the kind of set screw used, and defendant’s failure to warn plaintiff of the danger of wiping or cleaning the machinery while it was in motion.

The main grounds of defense seem to be contributory negligence and assumption of risk, in that the danger was an ordinary one, patent and obvious, and that the plaintiff ivas- in need of no instructions as to this particular danger. There is unquestionably evidence in this record to support each of the issues, specially mentioned above, relied upon by the plaintiff to make out his case; and there is likewise evidence to the contrary. There is evidence which, if believed, would authorize the jury to infer that the danger was not obvious, and that plaintiff was not aware of it, if others were, and that he was instructed to clean the machine while in motion. It is true that there is no evidence of any express or explicit instruction to clean the machine while in operation; but there was a direction given while it was in motion, and without specifying whether it should be done immediately, or be done after the mill was shut down. It is true that there is evidence of a custom or rule at the.mill to clean the machinery only after it was stopped and before the mill was closed for the week — that is, after 2:15 and before 3 p. m. But there is none that the plaintiff had been so instructed, or that he knew it was dangerous to clean the machinery in motion, though the jury might have inferred such conclusion. But there certainly could be no such conclusive presumption of such a state of facts as would take the question from the jury.

One -witness (Walter Riley) testified in part as follows : “There is no danger to clean the machinery while it is running if the set screw was taken off; .that there was no danger with the safety set screw, which is the same set screw that is screwed doAvn with a screwdriver ; that, if the set screw was taken off, there would be nothing to catch the waste.”

One John Allen testified as follows: “That there were two ways by which a set screw could be placed on a piece of shafting when it was exposed and revolving. It could be fixed with the long set screw with the head sticking up, or with the set screw with a flat head which came down flush with the collar, which would cause no danger at all; that an open-ended set screw could be used flush with the collar; that in all well-regulated shops they used an open-ended set screw which comes, when it is tightened on the shafting, flush with the collar; that the latter set screw, he thought, was used, as a rule, by up-to-date plants now; that this had been the rule for some time.”

The plaintiff testified in part as follows: To the question, “Did you know there was a set screw on it?” he answered: “No, sir; I did not know it. I had never seen it at all. I did not discover it.. The waste wrapped around my hand, and the waste got caught on the set screw. It was a long piece of shafting, about eight inches above the floor.” The transcript also shows, among others, the following questions to and answers by plaintiff: “Q. Did all of the employees in there clean their machines while running? A. Yes, sir; they had to clean then, or clean them on their own time. Q. What do you mean about their own time? A. At dinner; at noon. I was hurt before dinner. Mr. George Walls was the head boss. He was our superintendent and had charge of the room where I was at work, and was over me. When my hand got caught on the set screw, it just pulled my arm off.” On cross-examination plaintiff testified as follows: “Mr. Walls did not tell me to clean the machine while it was running, but simply told me to clean it. He did not tell me to clean it while the shaft was revolving, but he did not tell me not to clean it off while it was revolving, but he told me to clean it off and it was running when he told me. I had been working at this machine from Monday morning until Saturday morning.” Upon his redirect examination, in answer to a question, plaintiff stated: “I knew of no rule forbidding the cleaning of the machines while in operation.” To the question, “Was it your duty to wipe or clean them while they were in operation?” the defendant objected, upon the following grounds: “First, because it relates to matter about which the witness has been previously examined; also, because it relates to matter wbicb should have been brought out on chief examination.” The court overruled the objection, and defendant excepted, whereupon witness answered, “Yes, sir.” To the question, “Were you doing that at the time you Avere hurt?” the witness also replied, “Yes, sir.”

The defendant’s witness Walls on cross-examination testified as follows: “That he was the general boss of the spinning room of the Prattvillé Cotton Mills Company, and gave instructions and orders to the men directly under him. That right after plaintiff Avas injured. he removed the set screw and put in a flat headed set screw, but put it back on yesterday Avhile the case Avas in progress for the purpose of this trial.” To the question, “Did you not give instructions to the hands?” he ansAvered: “No, sir; not every time.” This witness further testified that he “did not remember giving Henry McKinney any instructions on the day he was hurt.”

To make a long story short, there is ample evidence in this record to carry the questions of liability of defendant, and contributory negligence and assumption of risk, on the part of the plaintiff, to the jury. Consequently, there was no error in the court’s declining to take these questions from the jury, or to set aside the verdict because not supported by the evidence; and this disposes of many of the assignments of error argued.

It is true that it has been held by some courts of very high authority — notably, the Supreme Court of Massachusetts — that the master is not liable, as matter of law, in running revolving shafting with set screws projecting therefrom as was the set screws in this case, claimed to have constituted a defect. And this, for the reason, it is said, that it is a common device or contrivance, if not a necessary one, in use in connection with such machinery. These same courts have also held that it is not actionable negligence on the part of the master to have such shafts and screws open and uninclosed, where it is shown that other masters, in like business, of reasonable and ordinary prudence, operate such machinery in the same manner. — Hale v. Cheney, 159 Mass. 268, 34 N. E. 255; Rooney v. Sewall, 161 Mass. 153, 159, 36 N. E. 789; Goodnow v. Walpole, 146 Mass. 261, 15 N. E. 576; Ford v. Mt. T. S. Co., 172 Mass. 544, 52 N. E. 1065, 48 L. R. A. 96, and note.

This court, however, has never sanctioned, to such extreme limit, the doctrine of the nonliability of the master. It is more nearly in line Avith those courts which hold; as to the liability of the master, that (a) “The common kiw implies a contract between a master and a servant Avhereby the former undertakes, through himself or his agents, to use reasonable care to furnish and maintain suitable and safe places, machinery, and appliances for the work to be done, to hire competent servants, and to warn the servant of all dangers of the AArork knoAvn to him and not known to the servant; and the latter undertakes to assume the risk of injury arising from the dangers of the Avork which he knows, or ought to knoAV, and the risk of injury caused by the negligence of all other servants in the common employment.” (b) “At common laAV, the master impliedly agrees to use reasonable care to provide reasonably safe premises and places in and about which the servant is required to work, to furnish reasonably safe and suitable machinery and a sufficient supply of proper materials, tools, and appliances for the work to be done, and at all times during the continuance of the work to repair and to keep in the same safe and suitable condition the places, machinery, and appliances.” (c) “The master is not an insurer, and is not required to provide the safest possible plant or to adopt the latest improvements, or to warrant against latent defects which a reasonable inspection would not disclose; but the dangers inherent in the nature of the woi’k must not be enhanced through his fault.” — 6 Mayf. Dig. 573.

Of course, statutes have imposed various and different duties and liabilities.

“It is often a question of fact and not of law whether or not a servant assumes the risk when he has knowledge of the defect and of danger attending the work. Though the servant may have knowledge both of the defect and of the danger, yet if against his judgment is set the judgment of a superior, who is an expert, who commands him to go on with the- work and therefore to run the risk, it then becomes a complex question whether the inferior is not justified in surrendering his own opinion and obeying the command of his superior. The nature and the degree of danger, the extent of the servant’s appreciation and understanding of the exigencies of the work all enter into consideration.— Birmingham Co. v. Skelton, 149 Ala. 465, 43 South. 110.” — 6 Mayf. Dig. 581.

“While a master is not required to use the best possible appliances, he may show that they were such as were adopted and used by many prudent persons engaged in the same business, yet this fact does not necessarily exempt the employer from liability. Prudent persons may do imprudent things and may fail to use proper appliances. — Davis v. Kornman, 141 Ala. 479, 37 South. 789.” 6 Mayf. Dig. 585.

“In Hough v. Railway Company, 100 U. S. 213 [25 L. Ed 612], it was.decided that among the established exceptions to the general rule as to the nonliability of the common employer to one employee for the negligence of a coemployee in the same service is one which arises from the obligation of the master, whether a natural person or a corporate body, not to expose the servant, when conducting the master’s, business, to perils or hazards against which he may be guarded by proper diligence upon the part of the master; that the master is bound to observe all the care which prudence and the exigencies of the situation require, in providing the servant with machinery or other instrumentalities adequately safe for use by the latter; and that it is implied in the contract between the master and the servant that, in selecting physical means and agencies for the' conduct of the business, the master shall not be wanting in proper care.” — Wabash R. Co. v. McDaniels, 107 U. S. 459, 2 Sup. Ct. 932, 27 L. Ed. 605.

Under these authorities, and the issues and the. evidence in this case, we are of the opinion that the liability of the master, and the contributory negligence and the assumption of risk by the servant, Avere questions properly left to the jury; and that the court did not err in declining to set aside the verdict for lack of evidence to support it.

We Avill noAV notice the assignments of error insisted -upon, Avhicli go, not to the right of recovery absolutely, but to errors to reverse the judgment rendered and to aAvard the defendant a new trial.

The court did not. err in allowing the witness Riley to testify that the machine in question Avas a dangerous one. The witness had sufficiently qualified to so testify.

The plaintiff Avas properly allowed to testify as to his knowledge of the dangerous character of the machinery which injured him.

There was no error in allowing testimony to the effect that this Avas the first injury or accident that happened at this particular machine. Such testimony certainly could not injure appellant, and it was competent for plaintiff to show his lack of knowledge of the dangerous character of the machine.

The question propounded to the witness, Walls, as to the machine’s being openly and visibly dangerous, was highly leading and affords ground sufficient to affirm the court in its action in sustaining an objection thereto. The evidence was admissible; but the form of the question was objectionable, though its allowance was within the discretion of the trial court.

Charge A was properly refused, because it confused the parties and, if given, would have been misleading. It was also bad otherwise, as in assuming as a question of law that it was dangerous to clean the machinery Avhile in motion. There was evidence to the contrary.

Charges B, I, J, and K were each bad, in that each requested the court to charge that there Avas no evidence of a given fact.

As before stated, there Avas also evidence which would authorize the jury in finding that plaintiff Avas instructed to clean the machinery Avhile in motion.

Charge E ignored certain tendencies of the evidence,to the effect that plaintiff had no knowledge of the dangerous character of the machinery, nor of the danger per se of the act of cleaning the machinery while in motion.

Charge G ignored certain tendencies of the evidence going to show a defect in the ways, works, machinery, etc., and thus took this question from the jury.

Charge L required the court to instruct the jury that there Avas no evidence of a given fact, and was bad.

Charge M tended to limit the recovery to a part only of the counts.

Charges O and P failed to limit plaintiff’s negligence to that which proximately contributed to the injury. Unless his negligence so contributed, it was no defense; but defendant received all the benefit to which it was entitled, under these charges, by the giving of charge D and F.

Charge T assumed as true a disputed fact; that is, that the plaintiff, before the injury, knew of the position of the set screw which caused his injury.

We are of the opinion that there is no reversible error in this record, and that the trial court properly denied the motion for a new trial.

Affirmed.

All the Justices concur, except Dowdell, C. J., not sitting.