130 U.S. 456 | SCOTUS | 1889
HURLBUT
v.
SCHILLINGER.
Supreme Court of United States.
Mr. L.L. Bond, (with whom was Mr. E.A. West on the brief,) for appellants.
Mr. George W. Hey, for appellees.
*457 MR. JUSTICE BLATCHFORD delivered the opinion of the court.
This is a suit in equity, brought in the Circuit Court of the United States for the Northern District of Illinois, by John J. Schillinger and Elmer J. Salisbury against J.B. Hurlbut, *458 founded on the alleged infringement of reissued letters patent, No. 4364, granted to John J. Schillinger, May 2, 1871, for an "improvement in concrete pavements," on the surrender of original letters patent No. 105,599, granted to said Schillinger, July 19, 1870. The defences set up in the answer are the invalidity of the reissue, want of utility in the invention, want of novelty and non-infringement.
The bill was filed in October, 1882. Salisbury having died, the suit was, so far as his interest was concerned, revived in March, 1884, in the name of Olive G. Salisbury, as administratrix. The interest of Salisbury was that he was the exclusive licensee under the reissued patent for the State of Illinois. Issue having been joined, proofs were taken on both sides, and on the 15th of May, 1884, the court entered an interlocutory decree, adjudging that the reissued patent was valid, that the defendant had infringed it, and that the administratrix of Salisbury recover profits and damages from the 26th of August, 1882, the date of the license to Salisbury. The decree also ordered a reference to a master to take an account of the profits and the damages.
The master took proofs, and on the 30th of September, 1884, filed his report, to the effect that between August 26, 1882, and May 20, 1884, the defendant had laid 70,909 feet of pavement by the use of the plaintiff's patent, for which he should be held to account; and that the plaintiffs had shown an established license fee of five cents a square foot, or $3545.45, as damages, which amount he reported. He also reported that the defendant's profits had amounted to four cents a square foot. The defendant excepted to this report, and, on a hearing, the court held that the evidence did not establish a fixed license fee as a royalty, and that the proper amount of recovery was the defendant's profits, at the rate of four cents a square foot, or $2836.36; and it entered a final decree, on the 16th of November, 1885, for that amount. The defendant has appealed from that decree.
The specifications, claims and drawings of the original and the reissued patents are as follows, the specifications and claims being placed in parallel columns, the parts of each *459 which are not found in the other being in italic, and the drawings of the original and the reissue being the same:
Original. Reissue.
"Be it known that I, John "Be it known that I, John
J. Schillinger, of the city, J. Schillinger, of the city,
county, and State of New county, and State of New
York, have invented a new York, have invented a new
and useful improvement in and useful improvement in
concrete pavements; and I concrete pavements; and I
do hereby declare the following do hereby declare the following
to be a full, clear, and exact to be a full, clear, and exact
description thereof, which description thereof, which
will enable those skilled in the will enable those skilled in the
art to make and use the same, art to make and use the same,
reference being had to the accompanying reference being had to the accompanying
drawing, forming drawing, forming
part of this specification, in part of this specification, in
which drawing which drawing
"Figure 1 represents my "Figure 1 represents a plan
pavement in plan view. Fig. of my pavement. Fig. 2 is a
2 is a vertical section of the vertical section of the same.
pavement. Similar letters indicate corresponding
parts.
*460
"This invention relates to "This invention relates to a
pavements for sidewalks and concrete pavement which is laid
other purposes, and consists in in sections, so that each section
combining, with the joints of can be taken up and relaid
concrete pavements, strips of without disturbing the adjoining
tar-paper or equivalent material sections. With the joints
arranged between the several of this sectional concrete pavement
blocks in such a manner are combined strips of
as to produce a suitable tight tar-paper or equivalent material
joint and yet allow the blocks arranged between the several
to be raised separately without blocks or sections in such
out affecting or injuring the a manner as to produce a suitable
blocks adjacent thereto. tight joint and yet allow
the blocks to be raised separately
without affecting the
blocks adjacent thereto.
"In carrying out my invention "In carrying out my invention
I form the concrete by I form the concrete by
mixing cement with sand and mixing cement with sand and
gravel or other suitable materials gravel or other suitable material
to form a suitable plastic to form a plastic compound,
composition, using about the using about the following
following proportions: One proportions: One part,
part, by measure, of cement; by measure, of cement; one
one part, by measure, of sand, part, by measure, of sand, and
and from three to six parts, from three to six parts by
by measure, of gravel, using measure, of gravel, with sufficient
sufficient water to make the water to render the mixture
mixture plastic; but I do not plastic; but I do not confine
confine myself to any proportions myself to any definite
for making the concrete proportions or materials for
composition. While the mass making the concrete composition.
*461
is plastic I lay or spread the While the mass is plastic
same upon the foundation or I lay or spread the same
bed of the pavement, either in on the foundation or bed of
moulds or between movable the pavement, either in moulds
joists of the proper thickness, or between movable joists of
so as to form the edges of the the proper thickness, so as to
concrete blocks a a, &c. When form the edges of the concrete
the block a has been formed I blocks a a, one block being
take strips of tar-paper b, of a formed after the other. When
width equal or almost equal to the first block has set I remove
the height of the block, and the joists or partitions from
place them up against the edges between it and the next block to
of the block in such a manner be formed, and then I form the
that they form the joints between second block, and so on, each
such block and the adjacent succeeding block being formed
blocks. After completing after the adjacent blocks have
one block, a, I place the set, [and since the concrete in
tar-paper b along the edge setting shrinks, the second block
where the next block is to when set does not adhere to the
be formed, and I put the plastic first, and so on,] and when the
composition for such next pavement is completed each
block up against the tar-paper block can be taken up independent
joint and proceed with the of the adjoining blocks.
formation of the new block Between the joints of the adjacent
until it is completed. In this blocks are placed strips
manner I proceed in making b of tar-paper or other suitable
all the blocks until the pavement material in the following manner:
is completed, interposing After completing one
tar-paper between their several block, a, I place the tar-paper
joints, as described. The b along the edge where the
paper constitutes a tight water-proof next block is to be formed,
joint, but it allows and I put the plastic composition
the several blocks to heave for such next block up
separately from the effects of against the tar-paper joint and
frost, or to be raised or removed proceed with the formation of
separately, whenever the new block until it is completed.
occasion may arise, without In this manner I proceed
injury to the adjacent blocks. until the pavement is
*462
The paper does not adhere completed, interposing tar-paper
when placed against the edge between the several joints,
of the fully formed block, and as described. The paper constitutes
therefore the joints are always a tight, water-proof
free between the several joint, but it allows the several
blocks, although adherence blocks to heave separately
may take place between from the effects of frost, or
the paper and the plastic edges to be raised or removed separately,
of the blocks which are formed whenever occasion may
after the paper joints are set arise, without injury to the
up in place. adjacent blocks. The paper
when placed against the block
first formed does not adhere
thereto, and therefore the
joints are always free between
the several blocks, although
the paper may adhere
to the edges of the block or
blocks formed after the same
has been set up in its place between
the joints. [In such
cases, however, where cheapness
is an object, the tar-paper
may be omitted and the blocks
formed without interposing
anything between their joints,
as previously described. In
this latter case the joints soon
fill up with sand or dust, and
the pavement is rendered sufficiently
tight for many purposes,
while the blocks are detached
from each other and
can be taken up and relaid
each independent of the adjoining
blocks.]
"What I claim as new and "What I claim as new and
desire to secure by letters-patent desire to secure by letters-patent
is is
*463
"The arrangement of tar-paper "1. A concrete pavement
paper or its equivalent between laid in detached blocks or sections,
adjoining blocks of concrete, substantially in the manner
substantially as and for shown and described.
the purpose described."
"2. The arrangement of
tar-paper or its equivalent between
adjoining blocks of concrete,
substantially as and for
the purpose set forth."
On the 1st of March, 1875, Schillinger filed in the Patent Office the following disclaimer: "To the Commissioner of Patents: Your petitioner, John J. Schillinger, of the city and county and State of New York, represents that letters patent of the United States, reissue No. 4364, bearing date May 2, 1871, were granted to him for an improvement in concrete pavements. That he has reason to believe that, through inadvertence, accident, or mistake, the specification and claim of said letters patent are too broad, including that of which your petitioner was not the first inventor, and he therefore hereby enters his disclaimer to the following words: `And since the concrete in setting shrinks, the second block when set does not adhere to the first, and so on,' and which occurs near the middle part of the said specification, and to the following words near the end of the specification: `In such cases, however, where cheapness is an object, the tar-paper may be omitted and the blocks formed without interposing anything between their joints, as previously described. In this latter case the joints soon fill up with sand or dust, and the pavement is rendered sufficiently tight for many purposes, while the blocks are detached from each other and can be taken up and relaid each independent of the adjoining blocks.' Your petitioner hereby disclaims the forming of blocks from plastic material without interposing anything between their joints while in the process of formation. Your petitioner owns the said patent and the whole interest therein, except in the following places or territory, for which he has granted exclusive licenses under royalty, or sold rights under said patent, to wit, the counties of *464 Kings, Queens, and Richmond, New York State; Hartford County, Connecticut; the District of Columbia; the States of New Jersey, Georgia, Maryland, Louisiana, Texas, Ohio, Michigan, Missouri and Illinois, which above-named States and places comprise all the territory for which he has sold or granted exclusive licenses or rights in or under said patent, to the best of his recollection, knowledge and belief."
The words specifically disclaimed by the disclaimer are embraced in brackets in the copy of the specification of the reissue above set forth.
The Schillinger patent has been before several of the Circuit Courts of the United States, and also before this court, for adjudication.
In the Circuit Court for the Southern District of New York, before Judge Shipman, in February, 1877, in Schillinger v. Gunther, 14 Blatchford, 152, and 2 Ban. & Ard. Pat. Cas. 544, and 11 Off. Gaz. 831, and in the same case, before Judge Blatchford, in August, 1879, 17 Blatchford, 66, and 4 Ban. & Ard. Pat. Cas. 479, and 16 Off. Gaz. 905; in the Circuit Court for the District of California, before Judge Sawyer, in May, 1881, in California Artificial Stone Paving Co. v. Molitor, and The Same v. Perine, 7 Sawyer, 190, and 8 Fed. Rep. 821, and 20 Off. Gaz. 813; in the Circuit Court for the Northern District of New York, before Judge Blatchford, in July, 1883, in Schillinger v. Greenway Brewing Co., 21 Blatchford, 383, and 17 Fed. Rep. 244, and 24 Off. Gaz. 495; and in the Circuit Court for the Southern District of Ohio, before Judge Sage, in June, 1884, in Kuhl v. Mueller, 21 Fed. Rep. 510, and 28 Off. Gaz. 541; the patent was sustained. In the Supreme Court of the District of Columbia, in general term, in July, 1885, in Schillinger v. Cranford, 4 Mackey, 450, and 37 Off. Gaz. 1349, it was held void, on the question of novelty. It was also interpreted by Judge Sawyer, in the Circuit Court for the District of California, in California Artificial Stone Paving Co. v. Freeborn, in January, 1883, 8 Sawyer, 443, and 17 Fed. Rep. 735, and by Judge Deady, in the Circuit Court for the District of Oregon, in August, 1887, in Schillinger v. Middleton, 31 Fed. Rep. 736.
*465 The patent was before this court in California Paving Co. v. Molitor, 113 U.S. 609, in March, 1885, but only on a question of contempt, and in California Paving Co. v. Schalicke, 119 U.S. 401, in December, 1886.
We are of opinion that the proper construction of the reissued patent is, that the invention consists in dividing the pavement into blocks, so that one block can be removed and repaired without injury to the rest of the pavement, the division being effected by either a permanent or a temporary interposition of something between the blocks. Concrete pavement had been laid before in sections, without being divided into blocks. The effect of the disclaimer was to leave the patent to be one for a pavement wherein the blocks are formed by interposing some separating material between them. To limit the patent to the permanent interposition of a material equivalent to tar-paper, would limit the actual invention. The use of a bottom layer of coarse cement, and placing on it a course of fine cement, and dividing the upper course into blocks by a trowel run partially or wholly through the upper course while it is plastic, in a line coincident with the joints between the sections in the lower layer, accomplishes the substantial results of Schillinger's invention, in substantially the way devised by him, and is within the patent as it stands after the disclaimer. The disclaimer took out of the first claim of the reissue only so much thereof as claimed a concrete pavement made of the plastic material laid in detached blocks, without interposing anything in the joints in the process of formation, leaving that claim to be one for such a pavement laid in detached blocks, when free joints are made between the blocks, by interposing permanently or temporarily between them, in the process of their formation, tar-paper or its equivalent.
In California Paving Co. v. Schalicke, (supra,) it was said, (p. 406:) "The evidence in the present case shows that the defendant, during the process of making his pavement, marked off its surface into squares. But the question is whether he, to any extent, divided it into blocks, so that the line of cracking was controlled, and induced to follow the joints of the divisions, rather than the body of the block, and so that a *466 block could be taken out, and a new one put in its place, without disturbing or injuring an adjoining block. The specification makes it essential that the pavement shall be so laid in sections `that each section can be taken up and relaid without disturbing the adjoining sections.' Again it says that the joint between the blocks `allows the several blocks to heave separately, from the effects of frost, or to be raised or removed separately, whenever occasion may arise, without injury to the adjacent blocks.' This is essential; and, in all the cases where infringement has been held to have been established, there have been blocks substantially separate, made so by the permanent or temporary interposition of a separating medium or a cutting instrument, so that one block could upheave or be removed without disturbing the adjoining blocks. The patentee, in the disclaimer, expressly disclaimed `the forming of blocks from plastic material without interposing anything between their joints while in the process of formation.' It appears that the defendant laid his pavement in strips from the curb of the sidewalk inward to the fence, in one mass, and then marked the strip crosswise with a blunt marker, which is made an exhibit, to the depth of about one sixteenth of an inch. But it is not shown that this produced any such division into blocks as the patent speaks of, even in degree. There were no blocks produced, and, of course, there was nothing interposed between blocks. The mass underneath was solid, in both layers, laterally. So far as appears, what the defendant did was just what the patentee disclaimed. The marking was only for ornamentation, and produced no free joints between blocks, and the evidence as to the condition of the defendant's pavements after they were laid shows that they did not have the characteristic features above mentioned as belonging to the patented pavement."
In its decision in the present case, which was made before that in the Schalicke case, the court said that the case was in no way different, so far as infringement was concerned, from the cases against Perine and Molitor and the case against the Greenway Brewing Company.
In the Schalicke case, it was said, in the opinion of this *467 court, in regard to the pavement in the Molitor case: "The defendant's pavement was made by cutting a lower course into sections with a trowel, to a greater or less depth, according to the character of the material, making a joint, and doing the same with an upper course, the upper joint being directly over the lower joint. Into the open joint, in each case, was loosely put some of the partially set material from the top of the laid course, answering the purpose of tar-paper. A blunt and rounded joint-marker, which was said to be 1/16 or 1/8 of an inch in depth, was then run over the line of the joints, marking off the block. The pavement was weaker along the line of the joint than in any other place. This was held to be an infringement." It was also there said that, in the Greenway Brewing Company case, "it was held that the 2d claim of the reissue was infringed by a concrete pavement which had an open cut made by a trowel entirely through two courses of material, the line of cut in the upper course being directly over the line of cut in the lower course, and that the interposition of the trowel, though temporary, was an equivalent for the tar-paper, even though the joint was left open after the trowel was removed, and was not made tight."
In the present case, the only pavement for which the defendant was held liable was what was called in his account or statement before the master "concrete flag pavement," the manner of constructing which is thus described by Mr. Perkins, a witness for the plaintiff: "First, joists are placed seven to eight feet apart, in front of the property where the work is to be laid. First, one stone is formed by placing a joist across between the others at right angles, generally at about four feet from the place of beginning. In this space a mortar, composed of sand, gravel and cement, is put and thoroughly tamped, so that the coarse material will be from three to four inches in thickness, leaving about one half inch on top for a mortar composed of sand and cement, which is trowelled off and made even with the top surface of the joists. Then the short joist that is put in at right angles, as before described, is taken up and placed about the same distance as before, and again filled in. The finer material in the coarse concrete is generally *468 worked next to the joist, so as to make a good, smooth, strong edge. When the top stuff is put on this last stone, and finished over on top with a trowel, the joint between the two stones being marked on the outer joist, a trowel is drawn through the top stuff, to make a joint straight, to correspond with the joint below." The evidence is satisfactory, that the trowel was used to cut through or into the top layer to an extent sufficient to make such a separation of the top layer into blocks, at a line corresponding with the joint below between the sections of the first layer, as to control the cracking of the top layer, by dividing it substantially into separate blocks. This division depends on the depth of the cut. The defendant contends that the object and effect of the marking with the trowel was only to give to the pavement the appearance of flagging; but the evidence is entirely clear, that the cut was made sufficiently deep, in proportion to the thickness of the upper layer, to make such a separation of the upper layer into blocks as would compel any tendency to crack to follow the line of the cut made by the trowel, and not run off into the body of the layer; and that thus the object of Schillinger's invention was attained. The defendant is, by the report of the master and the decree of the Circuit Court, made liable only for concrete flagging so laid and cut as to produce such result. The defendant was particular to have the cut in the upper layer made with the trowel directly over the line between the two sections of the lower layer, and it is shown that the upper layer of his pavement thus made would come up in separate blocks. He made his lower course of sand, gravel and cement, mixed in the proportions of one part of cement to six or seven of sand and gravel, while he made his upper course of one half sand and one half cement, made plastic with water. The lower course of his flagging was composed of material in which there was only one part of cement or adhesive substance to six or seven parts of non-adhesive substance, and there was but a slight tendency to adhere between the faces of the two sections in the lower course; while as the upper layer was composed one half of adhesive substance, the tendency was for its material to adhere strongly. Therefore, a cut in the *469 upper course, coincident with the joint below, would permit any action of the settling of the lower course, through frost or upheaval, to extend to the top of the upper course through a joint cut in that course, of sufficient depth to prevent the tendency of the upper course to crack in its body rather than in the line of the cut.
We are, therefore, of opinion that the first claim of the reissue, as it stands after the disclaimer, is infringed, because the defendant's pavement is a concrete pavement, laid in detached blocks or sections, substantially in the manner shown and described in the specification of the reissue, the detached blocks in the upper course being the equivalent of the detached blocks or sections of the Schillinger pavement; and that the second claim of the reissue is infringed, because the temporary use of the trowel or cutting instrument, to divide the upper course into blocks, is the equivalent of the tar-paper of the Schillinger patent, the cutting making a division which controls the cracking, and facilitates the taking up and relaying of the blocks or sections in the upper course "without disturbing the adjoining sections," and the trowel being interposed to effect its object during the process of forming the pavement on the spot where it is to remain.
The invention of Schillinger was a very valuable one. The evidence is that it entirely superseded the prior practice of laying concrete pavements in a continuous, adhering mass.
The defendant introduced in evidence, on the question of novelty, the following patents:
English patent to Claridge, No. 7489, of 1837; English patent to D'Harcourt, No. 7991, of 1839; United States patent to Russ, No. 5475, of 1848; English patent to Chesneau, No. 350, of 1852; English patent to Coignet, No. 2659, of 1855; English patent to De la Haichois, No. 771, of 1856; and United States patent to Van Camp, No. 93,142, of July 27, 1869. All of these patents, except the Van Camp patent, were introduced in evidence on the part of the defence in the case against the Greenway Brewing Company, and it was held in that case that none of them anticipated the Schillinger invention. A copy of the record in that case, embracing the *470 pleadings, and the evidence and patents put in by the defendant in it, on the question of novelty, forms part of the record in the present case.
An examination of the patents put in evidence by the defendant, in connection with the testimony in regard to them, shows that the Claridge pavement was not a concrete pavement, and was not formed in detachable blocks, but was a continuous asphalt pavement; that the D'Harcourt pavement was not a concrete pavement laid in detached blocks or sections, nor could one section be removed without disturbing adjacent sections; that the Russ patent shows a concrete foundation for a stone pavement, the pavement proper being constructed of granite or syenite placed on top of the concrete foundation, such concrete foundation not being formed in detachable blocks, but only being provided at certain places with removable panels, consisting of frames filled with concrete, to be lifted out to give access to water-pipes or for other purposes; that the Chesneau pavement was not a concrete pavement laid in detached sections or blocks, but was a continuous pavement, provided with panels to give access in certain places to gas and water-pipes, the panels being made of sections set in frames, which were removably inserted in the surrounding pavement, and there was no arrangement of tar-paper or its equivalent between adjoining blocks of concrete, for the purpose set forth in the Schillinger patent; that the Coignet patent did not show a concrete pavement, made in detachable blocks after the manner of Schillinger's, and built on the ground where it was to remain; that the De la Haichois pavement was not a concrete pavement laid in detachable blocks or sections, or having the arrangement of tar-paper or its equivalent between adjoining blocks of concrete, like that of Schillinger; and that the Van Camp patent showed only blocks formed in moulds, and removable from the moulds, or the pavement to be laid cemented in the moulds, and it not being stated that the blocks should be formed on the spot where they were to remain, nor that they should be formed of cement and gravel or sand. It further appears that, in the Van Camp patent, when the blocks are made in moulds, they are like *471 bricks, or artificial stones, or wooden blocks, which are prepared and then brought to the place where they are to be laid and put down in the usual manner; and that, when the blocks remain in the moulds and are thus laid, they do not present a uniform wearing surface of concrete, or constitute a concrete pavement formed in detachable blocks by joints.
Other testimony as to prior public use was introduced in this case, taken from the record in the case of Schillinger v. Phillip Best Brewing Co., in the Circuit Court for the Eastern District of Wisconsin, which testimony was also introduced in the case against the Greenway Brewing Company, having been taken in November, 1882. In the decision in the latter case, it was correctly said of that testimony: "So far as it refers to prior use in Germany, not shown in a patent or printed publication, it was duly objected to in this case and must be excluded. As to the cement malt floor which Row laid in Baltimore twenty-five years ago, he shows that it was not made in sections detachable by free joints. The testimony of Botzler as to a prior malt floor laid by him in Chicago is too indefinite to amount to sufficient evidence to defeat a patent." So far as that testimony related to a pavement used in Germany, it was objected to at the time it was introduced in this case, as incompetent. It was clearly inadmissible under § 4923 of the Revised Statutes, because it did not show anything that had been patented or described in a printed publication.
We do not think that the reissued patent, as it stood after the filing of the disclaimer, was open to the objection that it was not for the same invention as that of the original patent. Whatever there was of objectionable matter inserted in the specification or the first claim of the reissue, when it was granted, was removed by the disclaimer. The reissue was granted within ten months after the original. The single claim of the original patent was repeated in the reissue as the second claim of the latter, and the first claim of the reissue, as it stood after the disclaimer, did not expand beyond the claim of the original what was claimed in the reissue.
As to the amount of the decree, we think the court properly awarded the sum of four cents per square foot as the profits of *472 the defendant, and that it was right to give to the plaintiff the entire profits made by the defendant by the laying by him of his concrete flagging, in view of the testimony in the case. It clearly appears that the defendant's concrete flagging derived its entire value from the use of the plaintiff's invention, and that if it had not been laid in that way it would not have been laid at all.
In Elizabeth v. Nicholson Pavement Co., 97 U.S. 126, 139, it is said that "when the entire profit of a business or undertaking results from the use of the invention, the patentee will be entitled to recover the entire profits, if he elects that remedy." This language was quoted with approval in Root v. Railway Co., 105 U.S. 189, 203. As in the case of the Nicholson patent, so in the case of the Schillinger patent, the pavement was a complete combination in itself, differing from every other pavement, and the profit made by the defendant was a single profit derived from the construction of the pavement as an entirety. Callahan v. Myers, 128 U.S. 617, 665, 666.
Within the decision in Garretson v. Clark, 111 U.S. 120, the proof in this case is satisfactory, that the entire value of the defendant's pavement, as a marketable article, was properly and legally attributable to the invention of Schillinger.
The decree of the Circuit Court is
Affirmed.
