Enrico Fouch was diagnosed with silicosis and ultimately received a double-lung transplant due to his overexposure to silica sand while he worked for approximately 11 years as a sandblaster. Fouch subsequently filed suit against Mine Safety Appliances Company, Bicknell Supply Company, and Miles Supply of Elberton, Inc. (collectively, “the Defendants”), who manufactured or supplied safety equipment that Fouch used while sandblasting.
Fouch appeals from the trial court’s ruling, contending that the trial court erred in concluding that, in order to establish proximate cause, he was required to show the actual
Summary judgment is proper when there is no genuine issue of material fact and the movant is entitled to judgment as a matter of law. On appeal from the grant or denial of a motion for summary judgment, we review the evidence de novo, and all reasonable conclusions and inferences drawn from the evidence are construed in the light most favorable to the nonmovant.
(Citations, punctuation and footnote omitted.) MCG Health v. Barton,
So viewed, the evidence shows that Fouch worked as a sandblaster in the granite industry in Elberton, Georgia from 1996 to 2007. During that time, Fouch worked for two companies: Majestic Granite from 1996 to January 1999 and Superior Granite from January 1999 to October 2007.
At Majestic Granite, Greg Dubose taught Fouch how to sandblast and gave limited instruction on what protective gear Fouch could use for sandblasting. According to federal regulations dealing with respiratory protection, the only acceptable respirator to be used during abrasive sandblasting is the Type CE air-supplied respirator with a blast hood or helmet as part of the respirator unit (hereinafter an “air-supplied hood”). Dubose did not instruct Fouch that it was necessary to sandblast in an air-supplied hood, and neither of them used an air-supplied hood while sandblasting. Instead, Fouch and Dubose sandblasted while using a nonair-supplied canvas hood and either a paper mask or an air-supplied respirator underneath the hood. Every time Fouch sandblasted in an enclosed sandblasting room, he wore the nonair-supplied hood and an air-supplied respirator. Fouch knew that it was harmful to inhale the dust caused from sandblasting and that he had to wear respiratory equipment to protect against this hazard. Fouch stated that, while at Majestic Granite, the respirator he used was cleaned only a few times and he was never given an air-supplied hood.
At Majestic Granite, Fouch used several different types of sand, and he remembered seeing warning labels on the front of those bags about the need to avoid inhalation of the dust caused by sandblasting. Fouch, however, did not remember reading the language contained in those warning labels that prolonged exposure to crystal and silica had been shown to induce silicosis.
Majestic Granite purchased its respiratory equipment, including the nonair-supplied hoods, and sand from Miles Supply. The canvas hood contained a warning label advising that the hood did not provide respiratory protection, and only NIOSH-approved respirators should be used when sandblasting. Majestic Granite also purchased sand and equipment, including canvas hoods, from Bicknell Supply. Majestic Granite had a Dustfoe 66 respirator, which was manufactured by Mine Safety Appliances. The record contains no evidence of any discussions about what equipment Majestic Granite should purchase.
In January 1999, Fouch left Majestic Granite and began working for Superior Granite. Superior Granite provided Fouch with various types of respiratory protection — a paper dust mask, a nonairsupplied hood, an air-supplied respirator, and a nonair-supplied respirator. At first, Fouch used an air-supplied respirator, but subsequently he refused to wear it because the air flowing into the mask stung his eyes and smelled bad. When confronted by his supervisor, Charles Worley,
Fouch then selected and Charles Worley bought for Fouch a Dustfoe 66 respirator. Charles Worley believed that he first contacted Bicknell Supply to purchase the respirator, and when they did not have it, he went to Miles Supply. The Dustfoe 66 was later replaced with another unit and then with a Dustfoe 88 respirator. Eventually, Superior Granite replaced the Dustfoe 88 respirator with an air-supplied respirator.
Fouch used the Dustfoe respirators primarily for sandblasting, but he also used the Dustfoe during cleanup, shoveling, and sweeping of sand. Fouch wore three different Dustfoe respirators for a total period of approximately two years at Superior Granite. The Dustfoe respirators were not air-supplied, nor did they contain warnings that they were unfit for use in sandblasting.
Charles Worley had told Fouch of the dangers of sandblasting, and Worley testified that sandblasting with silica sand would not be a problem if the sandblaster wore respiratory protection, which, according to him, amounted to an air-supplied respirator and a mask. Charles Worley testified that Superior Granite primarily bought sand and respiratory equipment from Bicknell Supply and Miles Supply and that these suppliers sent salesmen to the job site. Business invoices reveal that Superior Granite purchased nonairsupplied hoods for sandblasting from both Bicknell Supply and Miles Supply. Miles Supply and Bicknell Supply never warned or advised Charles Worley as to what equipment he should use to protect a sandblaster, including the fact that an air-supplied hood was required for sandblasting in a sandblast room.
In late 2006 and early 2007, Fouch began having trouble breathing, had chest pains, began wheezing, and became easily fatigued. When the problems continued, Fouch quit his employment at Superior Granite in October 2007. In January 2008, Fouch was diagnosed with silicosis as a result of his work as a sandblaster, and he subsequently received a double-lung transplant. Fouch then filed the instant lawsuit.
Fouch identified three experts in support of his product liability and negligent failure to warn claims, all of whom were deposed: Dr. Vernon Rose is a certified industrial hygienist, a certified safety professional, and a professional engineer who worked for NIOSH in the 1970s; Dr. Edward Karnes is a human factors and warnings expert; and Darrell Bevis is an industrial hygienist who specializes in respiratory protection.
Dr. Rose specifically testified that nonair-supplied sandblasting hoods should have never been sold because “they essentially provide no protection against the inhalation of respirable silica airborne particles.” Dr. Rose opined that the nonair-supplied hoods would be misusedbecause workers would mistakenly think they were adequately protected and would be more willing to do hazardous work.
According to Dr. Rose, certain studies — such as the Boeing Study — revealed that individuals wearing a nonair-supplied hood are exposed to respirable silica at levels far exceeding the permissible exposure limit. These studies further found that small employers are not aware or do not fully appreciate the hazards of sandblasting or the potential for developing silicosis as a result of sandblasting. The Boeing Study has been publicly available since the early 1970s and would have been readily available to manufacturers and suppliers of sandblasting equipment, like the Defendants. Bevis testified that small sandblasting companies, like Fouch’s employers, rely on manufacturers and suppliers of sandblasting products to provide accurate and complete information about their products.
Dr. Karnes opined that neither Fouch nor his supervisor at Superior Granite, Charles Worley, had sufficient knowledge to appreciate the hazards of sandblasting. Dr. Rose believed that manufacturers and suppliers had a major responsibility to ensure that workers had the proper information and proper respiratory equipment, and that the nonair-supplied hoods should be accompanied by a warning label specifically stating that the hood is not to be used when sandblasting.
Based on his experience, Dr. Rose testified that if Fouch wore a nonair-supplied hood with a Dustfoe respirator while sandblasting, Fouch would have been overexposed to respirable silica. According to Dr. Rose, this overexposure would contribute to the development of a respiratory disease. Both Dr. Rose and Bevis opined that Fouch was overexposed to respiratory silica due to the improper respiratory protection he was provided.
1. Fouch contends that the trial court erred in granting summary judgment to Mine Safety Appliances and Bicknell Supply on proximate cause grounds. We agree.
Regardless of whether the plaintiff proceeds under a theory of negligence or strict liability, a plaintiff must prove as part of his case that the defendant’s product was the proximate cause of the injuries alleged. See John Crane, Inc. v. Jones,
In cases involving toxic chemicals, a plaintiff must offer proof of general causation —• that exposure to a substance is capable of causing a particular injury or disease — and proof of specific causation — that exposure to a substance under the circumstances of the case contributed to his illness or disease. See Butler v. Union Carbide Corp.,
In this case, it is undisputed that as a result of his sandblasting employment, Fouch contracted silicosis, which by definition, results only from an overexposure to silica. OCGA § 51-14-3 (22) (“Silicosis means nodular interstitial fibrosis of the lung produced by inhalation of silica.”) (punctuation omitted). As a result, Fouch did not have to establish that he was exposed to a specific threshold level of silica necessary to induce silicosis. See Fulmore, supra,
It is also undisputed that the only acceptable respirator to be used during abrasive sandblasting that was primarily involved in this case is an air-supplied hood. Moreover, the undisputed evidence showed that Fouch did not wear the required respiratory equipment during his employment with Majestic Granite and Superior Granite. At Majestic Granite, Fouch sandblasted while using a canvas, nonairsupplied hood and either a paper mask or an air-supplied respirator underneath the hood. The canvas hoods were supplied, in part, by Bicknell Supply. At Superior Granite, Fouch wore three Dustfoe respirators that were manufactured by Mine Safety Appliances.
Fouch’s experts — Dr. Rose and Bevis — testified that, based upon the Boeing Study that had been available since the 1970s, Fouch was overexposed to respirable silica because the study showed that respirable silica levels far exceeded the permissible limit when wearing nonair-supplied hoods. According to Dr. Rose, this overexposure would contribute to the development of a respiratory disease.
In Fulmore, the plaintiffs’ experts testified that the plaintiffs’ exposures to visible dust from the use of asbestos-containing products exceeded the permissible threshold values. Fulmore, supra,
Contrary to the assertions by Bicknell Supply and Mine Safety Appliances, this Court’s decision in Butler, supra, does not compel a different result. In Butler, the trial court, after conducting a rigorous Daubert analysis, as distinguished from the lack of such analysis in this case, struck the opinion of a proffered expert because he relied upon an untested theory that any exposure to asbestos would contribute to the development of mesothelioma; relied upon a study that was not limited to the type of asbestos involved in the case; and overestimated the amount of asbestos to which the plaintiff had been exposed. Butler, supra,
Since the trial court granted summary judgment to Mine Safety Appliances on Fouch’s strict liability claim on the ground that he failed to create a factual question on the issue of proximate cause, the grant of summary judgment on the strict liability claim was erroneous, and the claim is, therefore, still viable. We need not discuss Fouch’s arguments on the matter any further. Consequently, we reverse the trial court’s grant of summary judgment on the strict liability claim against Mine Safety Appliances.
2. Fouch also contends that the trial court erred in finding that the Defendants had no duty to warn him or his employers of the dangers posed by sandblasting with their products. We agree that questions of fact remain on this issue.
Under Georgia law, “the manufacturer of a product which, to its actual or constructive knowledge, involves danger to users, has a duty to give warning of such danger.” (Citations and punctuation omitted.) Chrysler Corp. v. Batten,
Whether a duty to warn exists depends upon foreseeability of the use in question,the type of danger involved, and the foreseeability of the user’s knowledge of the danger. Such matters generally are not susceptible of summary adjudication and should be resolved by a trial in the ordinary manner.
(Punctuation and footnote omitted.) R & R Insulation Svcs. v. Royal Indem. Co.,
Nevertheless, a manufacturer or distributor has no duty to warn of a product-connected danger which is obvious or generally known. R & R Insulation, supra,
In this case, Fouch admits that he knew of the general risks associated with sandblasting and that he was required to wear respiratory protection. A factual issue remains, however, regarding whether Fouch was aware of the specific risks of using the Defendants’ products. According to the testimony of Fouch’s experts, the Boeing Study — which has been publicly available since the 1970s — revealed that small employers are not aware or do not fully appreciate the hazards of sandblasting or the potential for developing silicosis as a result of sandblasting. Indeed, Fouch’s supervisor at Superior Granite, Charles Worley, wrongly believed that an air-supplied respirator and mask were sufficient respiratory protection against the dangers of sandblasting with silica sand. Similarly, the person who trained Fouch at Majestic Granite wore the same equipment that Fouch did when he sandblasted, which is to say that he did not wear sufficient protection either. Moreover, it is undisputed that Fouch’s employers never supplied the proper equipment — an air-supplied hood, as opposed to an air-supplied respirator — that would have adequately protected Fouch while sandblasting.
Fouch’s industrial hygienist expert, Bevis, testified that small sandblasting companies, like Fouch’s employers, rely on manufacturers and suppliers of sandblasting products to provide accurate and complete information about their products. Fouch’s experts testified that the Defendants’ warnings were inadequate to properly warn Fouch that their equipment should not be generally used for the type of sandblasting Fouch was conducting. In particular, Mine Safety Appliances’ Dustfoe respirators had no warning at all that they were unfit for use in sandblasting. Additionally, although the canvas nonair-supplied hoods and sand bags that were distributed by Bicknell Supply and Miles Supply warned that only NIOSH-approved respirators should be used when sandblasting, Miles Supply’s catalogue referenced the nonair-supplied hood as a “sandblast hood,” which in Bevis’s opinion would lead small employers to believe they were buying proper respiratory equipment. Similarly, the evidence shows that Bicknell Supply’s representation that its canvas hood would provide adequate respiratory protection when used with a respirator underneath was improper according to Fouch’s expert because such a configuration was not adequate under the circumstances in which Fouch sandblasted. Moreover, one catalogue from Bicknell Supply contained no warning stating that the canvas hood did not provide respiratory protection or that proper respiratory equipment must be used with the hood.
Consequently, the trial court’s conclusion that Fouch was charged as a matter of law with the knowledge of the dangers of using the nonair-supplied hoods and respirators is not supported by the facts construed in the light most favorable to him. Additionally, to the extent the Defendants rely upon Stiltjes v. Ridco Exterminating Co.,
Judgment reversed.
Notes
Other named defendants were dismissed from the case.
Fouch does not challenge the trial court’s ruling that Bicknell Supply and Miles Supply were entitled to summary judgment on Fouch’s strict liability claim based on design defects. There is no dispute that Miles Supply and Bicknell Supply did not manufacture any of the equipment upon which Fouch’s claims are based. Therefore, Bicknell Supply and Miles Supply were entitled to summary judgment on this claim. See OCGA §§ 51-1-11 (b) (1), 51-1-11.1 (a), (b); Farmex Inc. v. Wainwright,
The warnings stated:
WARNING LUNG HAZARD
Use of this product especially for sandblasting requires the use of [Mine Safety Health Administration (“MSHA”)/National Institute for Occupational Safety and Health (“NIOSH”)) approved continuous flow [Type-CE air-supplied hood] in accordance with Federal OSHA regulations contained in 29 CFR 1910.94. All persons associated with sandblasting operations must be adequately trained in the use of, and provided with the appropriate respirator to prevent prolonged inhalation of crystalline silica in excess of the limits set in 29 CFR 1910.1000.
Prolonged exposure to crystalline silica has been shown to induce silicosis. . . .
The record also contains a Bicknell Supply catalogue from March 2007 that shows the canvas hood being marketed as a sandblasting accessory and which did not contain a warning that the hood did not provide respiratory protection or that proper respiratory equipment must be used with the hood.
We note that for certain asbestos and silica claims that accrued after May 1, 2007, a claimant is required to show that exposure to asbestos or silica was a substantial contributing factor in the person’s disease. OCGA § 51-14-3 (17) (B) (ii) (for asbestos claims alleging cancer other than mesothelioma), (18) (B) (i) (for silica-related cancer claims). Fouch’s silica claim was based on progressive massive fibrosis, and the “substantial contributing factor” element is not required for such claims. See OCGA § 51-14-3 (18) (B) (ii).
Daubert v. Merrell Dow Pharmaceuticals,
OCGA § 24-9-67.1 was repealed on January 1, 2013, coinciding with the effective date of Georgia’s new Evidence Code, and replaced by OCGA § 24-7-702.
To the extent Fouch may have been responsible for some of his injury due to his failure to wear any respiratory protection at all during some of the time he was employed by Majestic Granite and Superior Granite, he is not necessarily precluded from obtaining relief. Instead, he may be apportioned some share of fault for his own injury. OCGA § 51-12-33 (a).